Skip to content

7 open safety recalls recorded with NHTSA. A recall repair is free at a franchised dealer, whatever the age of the vehicle.

  1. STRUCTURE

    Thor Motor Coach (TMC) is recalling certain 2019 Challenger, Palazzo, Tuscany, 2019-2020 Miramar, 2019-2021 Aria, Outlaw, and Venetian recreational vehicles equipped with Hehr 6400 series windows. The adhesive that bonds the vented portion of the window may fail.

    Risk
    Adhesive failure may cause the vent portion of the window to detach, increasing the risk of a crash or injury.
    Remedy
    Dealers will inspect the windows, and replace the vent if necessary, free of charge. Owner notification letters were mailed September 8, 2021. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000232.

    NHTSA campaign 21V522000 · Thor Motor Coach · Reported 08/07/2021

  2. EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

    Thor Motor Coach (TMC) is recalling certain 2019-2020 Challenger, Miramar, Magnitude, Outlaw, Omni, and Palazzo motorhomes. The vehicle control system software may cause the slide-out room to move unexpectedly.

    Risk
    Unexpected movement of the slide-out room can increase the risk of a injury.
    Remedy
    TMC will notify owners, and dealers will update the affected software, free of charge. The recall is expected to begin August 28, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000170.

    NHTSA campaign 19V504000 · Thor Motor Coach · Reported 30/06/2019

  3. VISIBILITY

    Thor Motor Coach (TMC) is recalling certain 2017-2019 Thor Challenger, Miramar, and Outlaw motorhomes. The motorized windshield roller shade at the driver's seating position may unroll without warning while driving.

    Risk
    If the windshield roller shade unrolls while driving, it could block the driver's visibility, increasing the risk of a crash.
    Remedy
    TMC will notify owners, and dealers will install a fastener to ensure the motor will not allow the shade to roll down during while driving. The recall began January 10, 2019. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000165.

    NHTSA campaign 18V812000 · Thor Motor Coach · Reported 16/11/2018

  4. ELECTRICAL SYSTEM

    Thor Motor Coach (TMC) is recalling certain 2018-2019 Outlaw motorhomes, model 29J. The 12V wiring for the coach may have been improperly wired to the battery instead of wired through a circuit breaker.

    Risk
    In the event of an electrical short circuit, the unprotected circuit can increase the risk of a fire.
    Remedy
    TMC will notify owners, and dealers will correct the circuit's wiring, free of charge. The recall began October 9, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000160.

    NHTSA campaign 18V572000 · Thor Motor Coach · Reported 29/08/2018

  5. VISIBILITY

    Thor Motor Coach (TMC) is recalling certain 2018-2019 Thor Outlaw motorhomes, model 29J. These vehicles were manufactured without the rear reflex reflectors, which can make the vehicle less visible to other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

    Risk
    Missing rear reflex reflectors can make the vehicle less visible to other drivers, increasing the risk of a crash.
    Remedy
    TMC will notify owners, and dealers will install the missing reflectors, free of charge. The recall began on August 16, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC0000157.

    NHTSA campaign 18V482000 · Thor Motor Coach · Reported 19/07/2018

  6. SUSPENSION:REAR:SPRINGS:LEAF SPRING ASSEMBLY:U-BOLT, LEAF SPRING TO AXLE

    Thor Motor Coach (TMC) is recalling certain 2019 Thor Four Winds, Chateau, Freedom Elite, Majestic, Outlaw, Quantum and Vegas motorhomes built on modified Ford E-450 chassis. The U-bolts on the rear axle that hold the leaf spring and rear axle together may have been insufficiently tightened.

    Risk
    The loose U-bolts may further loosen or break allowing the axle to separate and cause a loss of control, increasing the risk of a crash.
    Remedy
    TMC has notified owners, and dealers will tighten U-bolts to the proper torque, free of charge. The recall began on June 22, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000156.

    NHTSA campaign 18V385000 · Thor Motor Coach · Reported 08/06/2018

  7. SEAT BELTS: REAR/OTHER:BUCKLE ASSEMBLY

    Thor Motor Coach (TMC) is recalling certain 2018-2019 Outlaw recreational vehicles, model 29J. The sofa seat belt bracket may not meet the strength requirements and may not adequately restrain an occupant in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 210, "Seat Belt Assembly Anchorages."

    Risk
    If the bracket does not meet the strength requirements, the anchorage may fail in the event of a crash, increasing the risk of injury.
    Remedy
    TMC will notify owners, and dealers will install a new bracket, free of charge. The recall began on April 4, 2018. Owners may contact TMC customer service at 1-877-855-2867. TMC's number for this recall is RC000151.

    NHTSA campaign 18V120000 · Thor Motor Coach · Reported 19/02/2018

Is your 2019 Thor Motor Coach Outlaw affected?

A recall applies to a range of vehicles, not to every one built that year. Check your VIN to see which of these are open on yours.

Source: NHTSA public recall database.

Recalls are issued every week. Most owners hear late.

Don’t miss the next recall

Free · No sign-up · iPhone & Android

Keep this vehicle checked automatically

DriveDocket checks every vehicle you add against the same NHTSA data and tells you when something new is filed against it.

Download on theApp StoreGet it onGoogle Play

Recall information comes from the National Highway Traffic Safety Administration, last updated 2021-07-08. DriveDocket is not affiliated with NHTSA, Thor Motor Coach, or any vehicle manufacturer. Confirm any recall with a franchised dealer before relying on it.

All Thor Motor Coach recalls

2019 Thor Motor Coach Outlaw recalls — DriveDocket